ライブラリ登録: Guest
Begell Digital Portal Begellデジタルライブラリー 電子書籍 ジャーナル 参考文献と会報 リサーチ集
Heat Transfer Research
インパクトファクター: 0.404 5年インパクトファクター: 0.8 SJR: 0.264 SNIP: 0.504 CiteScore™: 0.88

ISSN 印刷: 1064-2285
ISSN オンライン: 2162-6561

巻:
巻 50, 2019 巻 49, 2018 巻 48, 2017 巻 47, 2016 巻 46, 2015 巻 45, 2014 巻 44, 2013 巻 43, 2012 巻 42, 2011 巻 41, 2010 巻 40, 2009 巻 39, 2008 巻 38, 2007 巻 37, 2006 巻 36, 2005 巻 35, 2004 巻 34, 2003 巻 33, 2002 巻 32, 2001 巻 31, 2000 巻 30, 1999 巻 29, 1998 巻 28, 1997

Heat Transfer Research

DOI: 10.1615/HeatTransRes.2018026222
pages 851-863

ENHANCING THE THERMAL PERFORMANCE OF A MICRO FINNED TUBE WITH TiO2–WATER NANOFLUIDS USING TWISTED TAPE INSERTS

D. Mageshbabu
Department of Mechanical Engineering, S.A. Engineering College, Chennai-600077, Tamil Nadu, India
A. E. Kabeel
Mechanical Power Engineering Department, Faculty of Engineering, Tanta University, Egypt
Ravishankar Sathyamurthy
Mechanical Power Engineering Department, Faculty of Engineering, Tanta University, Egypt; Department of Automobile Engineering, Hindustan Institute of Technology and Science, Chennai- 603103, Tamil Nadu, India
S. A. El-Agouz
Mechanical Power Engineering Department, Faculty of Engineering, Tanta University, Egypt
Ali J. Chamkha
Department of Mechanical Engineering, Prince Sultan Endowment for Energy and Environment, Prince Mohammad Bin Fahd University, Al-Khobar 31952, Kingdom of Saudi Arabia; RAK Research and Innovation Center, American University of Ras Al Khaimah, United Arab Emirates, 10021
M. S. Girija
Department of Computer Science and Engineering, Jeppiaar Engineering College, Chennai-600119, Tamil Nadu, India
B. Madhu
Department of Mechanical Engineering, Velammal Institute of Technology, Chennai, Tamil Nadu, India

要約

This paper investigates the heat transfer characteristics and friction factor of finned microtube fitted with twisted tape inserts. Results show that the performance of the finned microtube with nanofluid depends on concentration of nanoparticles, pitch ratio, and the type of the pitch used. With increase in the concentration of nanoparticle with the base fluid the viscosity of the nanofluid increased by 30% compared to the fluid with concentration of 0.05%. The increase in the concentration of nanoparticles leads to increased pressure drop and pumping power. For the Reynolds number Re = 2000, the maximum performance ratio is found to be 1.5, 2.05, 2.1, and 2 for 0, 0.05, 0.1, and 0.2% concentration ratio, respectively. Similarly, with increase in the Reynolds number from 2000 to 10,000 the performance ratio decreases. Moreover, the results of performance ratio revealed that the use of a nanofluid have performance more than unity. Similarly, the performance of finned microtube heat exchanger is higher in the case of twist ratio (LR-Y = 6) and concentration ratio (φ = 0.2%), as the turbulence inside the tube is greatly influenced by the boundary layer separation by the inserts for enhanced friction ratio (f/fp) and Nusselt number ratio (Nu/Nup) compared to a smooth plain tube.

参考

  1. Akhavan, M.A.B., Ghazvini, M., and Rasouli, E., Experimental Investigation on Heat Transfer and Pressure Drop of Nanodiamond- Engine Oil Nanofluid in a Microfin Tube, in Proc. 14th Int. Heat Transf. Conf., pp. 617–623, 2010.

  2. Colla, L., Fedele, L., and Buschmann, M.H., Laminar Mixed Convection of TiO<sub>2</sub>–Water Nanofluid in Horizontal Uniformly Heated Pipe Flow, Int. J. Therm. Sci., vol. 97, pp. 26–40, 2015.

  3. Eiamsa-ard, S., Kiatkittipong, K., and Jedsadaratanachai, W., Heat Transfer Enhancement of TiO<sub>2</sub>/Water Nanofluid in a Heat Exchanger Tube Equipped with Overlapped Dual Twisted-Tapes, Eng. Sci. Technol. Int. J., vol. 18, no. 3, pp. 336–350, 2015.

  4. Ghadimi, A., and Ibrahim H.M., The Influence of Surfactant and Ultrasonic Processing on Improvement of Stability, Thermal Conductivity and Viscosity of Titania Nanofluid, Exp. Therm. Fluid Sci., vol. 51, pp. 1–9, 2013.

  5. Heris, S.Z., Etemad, S.G., and Nasr Esfahany, M., Experimental Investigation of Oxide Nanofluids Laminar Flow Convective Heat Transfer, Int. Commun. Heat Mass Transf., vol. 33, no. 4, pp. 529–535, 2006.

  6. Hussein, A.M., Rosli, A.B., Kumaran, K., and Karada, V.S., Heat Transfer Enhancement with Elliptical Tube under Turbulent Flow TiO<sub>2</sub>–Water Nanofluid, Therm. Sci., vol. 20, no. 1, pp. 89–97, 2016.

  7. Karami, M., Mohammad, A.A., and Mohammad, F., Heat Transfer and Pressure Drop Characteristics of Nanofluid Flows Inside Corrugated Tubes, Heat Transf. Eng., vol. 37, no. 1, pp. 106–114, 2016.

  8. Kayaci, N., Balcilar, M., Tabatabaei, M., Celen, A., Yildiz, O., Dalkilic, A.S., and Wongwises, S., Determination of the Single-Phase Forced Convection Heat Transfer Characteristics of TiO<sub>2</sub> Nanofluids Flowing in Smooth and Micro-Fin Tubes by Means of CFD and ANN Analyses, Current Nanosci., vol. 9, no. 1, pp. 61–80, 2013.

  9. Kazemi, B.A., Heris, S.Z., Moghadam, N., Shariati-Niasar, M., and Hamidi, A.A., Experimental Investigation of Parameters Affecting Nanofluid Effective Thermal Conductivity, Chem. Eng. Commun., vol. 201, no. 5, pp. 593–611, 2014.

  10. Khdher, A.M., Nor A.C., Rizalman, M., and Wan, A.W.H., Experimental and Numerical Study of Thermo-Hydraulic Performance of Circumferentially Ribbed Tube with Al<sub>2</sub>O<sub>3</sub> Nanofluid, Int. Commun. Heat Mass Transf., vol. 69, pp. 34–40, 2015.

  11. Kumar, R., Sood, S., Sheikholeslami, M., and Shehzad, S.A., Nonlinear Thermal Radiation and Cubic Autocatalysis Chemical Reaction Effects on the Flow of Stretched Nanofluid under Rotational Oscillations, J. Colloid Interface Sci., vol. 505, p. 253, 2017.

  12. Mageshbabu, D., Nagarajan, P.K., Sathyamurthy, R., and Suseel Jai Krishnan, S., Enhancing the Thermal Performance of Al<sub>2</sub>O<sub>3</sub>/DI Water Nanofluids in Micro-Fin Tube Equipped with Straight and Left-Right Twisted-Tapes in Turbulent Flow Regime, Exp. Heat Transf., vol. 30, no. 4, pp. 267–283, 2017a.

  13. Mageshbabu, D., Nagarajan, P.K., Madhu, B. and Ravishankar, S., Experimental Evaluation of Friction Factor and Heat Transfer Enhancement of Twisted Tape Inserts Using TiO<sub>2</sub>–Water Nanofluids, J. Eng. Thermophys., vol. 26, no. 4, pp. 567–579, 2017b.

  14. Mahanthesh, B., Gireesha, B.J., Shashikumar, N.S., and Shehzad, S.A., Marangoni Convective MHD Flow of SWCNT and MWCNT Nanoliquids Due to a Disk with Solar Radiation and Irregular Heat Source, Physica E: Low-Dimensional Syst. Nanostruct., vol. 94, pp. 25–30, 2017.

  15. Ouyahia, S., Youb, K.B., and Nabila, L., Numerical Study of the Hydrodynamic and Thermal Proprieties of Titanium Dioxide Nanofluids Trapped in a Triangular Geometry, Arab. J. Sci. Eng., vol. 41, no. 5, pp. 1995–2009, 2016.

  16. Said, Z., Saidur, R., Hepbasli, A., and Rahim, N.A., New Thermo Physical Properties of Water based TiO<sub>2</sub> Nanofluid—The Hysteresis Phenomenon Revisited, Int. Commun. Heat Mass Transf., vol. 58, pp. 85–95, 2014.

  17. Sajadi, A.R. and Kazemi, M.H., Investigation of Turbulent Convective Heat Transfer and Pressure Drop of TiO<sub>2</sub>/Water Nanofluid in Circular Tube, Int. Commun. Heat Mass Transf., vol. 38, no. 10, pp. 1474–1478, 2011.

  18. Salimpour, M.R. and Amir, D., Convective Heat Transfer of Nanofluid Flow through Conduits with Different Cross-Sectional Shapes, J. Mech. Sci. Technol., vol. 29, no. 2, pp. 707–713, 2015.

  19. Sheikholeslami, M. and Shehzad, S.A., CVFEM for Influence of External Magnetic Source on Fe<sub>3</sub>O<sub>4</sub>–H<sub>2</sub>O Nanofluid Behavior in a Permeable Cavity Considering Shape Effect, Int. J. Heat Mass Transf., vol. 115, pp. 180–191, 2017a.

  20. Sheikholeslami, M. and Shehzad, S.A., Magnetohydrodynamic Nanofluid Convective Flow in a Porous Enclosure by Means of LBM, Int. J. Heat Mass Transf., vol. 113, pp. 796–805, 2017b.

  21. Sheikholeslami, M. and Shehzad, S.A., Magnetohydrodynamic Nanofluid Convection in a Porous Enclosure Considering Heat Flux Boundary Condition, Int. J. Heat Mass Transf., vol. 106, pp. 1261–1269, 2017c.

  22. Sheikholeslami, M. and Shehzad, S.A., Thermal Radiation of Ferrofluid in Existence of Lorentz Forces Considering Variable Viscosity, Int. J. Heat Mass Transf., vol. 109, pp. 82–92, 2017d.

  23. Sivakumar, N., Durga Prasad, P., Raju, C.S.K., Varma, S.V.K., and Shehzad, S.A., Partial Slip and Dissipation on MHD Radiative Ferro-Fluid over a Non-Linear Permeable Convectively Heated Stretching Sheet, Results Phys., vol. 7, pp. 1940–1949, 2017.

  24. Sonawane, S.S., Rohit, S.K., and Kailas, L.W., Study on Concentric Tube Heat Exchanger Heat Transfer Performance Using Al<sub>2</sub>O<sub>3</sub>–Water Based Nanofluids, Int. Commun. Heat Mass Transf., vol. 49, pp. 60–68, 2013.


Articles with similar content:

The characteristics of heat transfer and flow resistance in a rectangular channel with vortex generators
Second Thermal and Fluids Engineering Conference, Vol.30, 2017, issue
Jing-tao Wang, Zhi-min Han, Zhi-ming Xu, Zuo-dong Liu
Convective Heat Transfer in a Wavy Channel Utilizing Nanofluids
Journal of Enhanced Heat Transfer, Vol.14, 2007, issue 4
Javad Rostami
NUMERICAL AND EXPERIMENTAL STUDY OF FLOW AND HEAT TRANSFER IN OUTWARDLY CONVEX CORRUGATED TUBES WITH A TWISTED TAPE INSERT
Heat Transfer Research, Vol.49, 2018, issue 16
Longbin Yang, Xin Chen, Bingxi Li, Huaizhi Han
EXPERIMENTAL INVESTIGATION OF THE EFFECT OF FLOW BLOCKAGES ON HEAT TRANSFER AND FLUID FRICTION IN A ROUND TUBE USING WALL-ATTACHED CIRCULAR RINGS
Heat Transfer Research, Vol.50, 2019, issue 1
Narayan K. Sane, Sandeep S. Kore, Adhikrao Patil
THE EFFECT OF CHAMFER LENGTH ON THERMAL AND HYDRAULIC PERFORMANCE BY USING Al2O3-WATER NANOFLUID THROUGH A SQUARE CROSS-SECTIONAL DUCT
Heat Transfer Research, Vol.50, 2019, issue 12
Orhan Keklikcioglu, Veysel Ozceyhan, Toygun Dagdevir