图书馆订阅: Guest
雾化与喷雾

每年出版 12 

ISSN 打印: 1044-5110

ISSN 在线: 1936-2684

The Impact Factor measures the average number of citations received in a particular year by papers published in the journal during the two preceding years. 2017 Journal Citation Reports (Clarivate Analytics, 2018) IF: 1.2 To calculate the five year Impact Factor, citations are counted in 2017 to the previous five years and divided by the source items published in the previous five years. 2017 Journal Citation Reports (Clarivate Analytics, 2018) 5-Year IF: 1.8 The Immediacy Index is the average number of times an article is cited in the year it is published. The journal Immediacy Index indicates how quickly articles in a journal are cited. Immediacy Index: 0.3 The Eigenfactor score, developed by Jevin West and Carl Bergstrom at the University of Washington, is a rating of the total importance of a scientific journal. Journals are rated according to the number of incoming citations, with citations from highly ranked journals weighted to make a larger contribution to the eigenfactor than those from poorly ranked journals. Eigenfactor: 0.00095 The Journal Citation Indicator (JCI) is a single measurement of the field-normalized citation impact of journals in the Web of Science Core Collection across disciplines. The key words here are that the metric is normalized and cross-disciplinary. JCI: 0.28 SJR: 0.341 SNIP: 0.536 CiteScore™:: 1.9 H-Index: 57

Indexed in

EFFECT OF SEMICYLINDRICAL COUNTER ELECTRODES ON THE CONE-JET MODE OF ELECTROSPRAY

卷 30, 册 1, 2020, pp. 11-29
DOI: 10.1615/AtomizSpr.2020031830
Get accessGet access

摘要

The effect of counter electrode curvature on the onset voltage and spray angle of the electrospray in the cone-jet mode is experimentally investigated. Six counter electrodes, including a conventional flat electrode, and five curved (both concave and convex) electrodes are considered. The curvature of the curved electrodes was in the range of 10−33.3 m-1. The applied voltage, the voltage range of the cone-jet mode, and geometrical features such as the liquid cone length and spray angle are measured. It was observed that the ground electrode curvature could manipulate the electric field and equipotential lines in a way that results in higher or lower onset voltage of the cone-jet mode for convex and concave electrodes, respectively. In addition, the operating range or "stability island" grows by convex electrodes and decreases by concave electrodes. Simulation of electric potential lines is introduced to explain this effect further. In general, the ground electrode shape can intensify or abate the density of the equipotential lines in the vicinity of the liquid meniscus at the capillary tip. The cone-jet mode onset voltage equation is modified to include this effect. Moreover, the spray shape was affected by the curved electrodes. In both configurations, the spray angle increases; however, in the case of the concave electrodes, the actual spray coverage is much closer to the theoretical spray coverage.

参考文献
  1. Alexander, M.S., Stark, J., Smith, K.L., Stevens, B., and Kent, B., Electrospray Performance of Microfabricated Colloid Thruster Arrays, J. Propul. Power, vol. 22, no. 3, pp. 620-627, 2006.

  2. Allaf-Akbari, E. and Ashgriz, N., An Electrospray in a Gaseous Crossflow, J. Aerosol Sci., vol. 114, pp. 233-243,2017.

  3. Balachandran, W., Miao, P., and Xiao, P., Electrospray of Fine Droplets of Ceramic Suspensions for Thin-Film Preparation, J. Electrost., vol. 50, no. 4, pp. 249-263,2001.

  4. Chiarot, P.R., Sullivan, P., and Ben Mrad, R., An Overview of Electrospray Applications in MEMS and Microfluidic Systems, J. Microelectromech. Syst., vol. 20, no. 6, pp. 1241-1249,2011.

  5. Ciach, T., Microencapsulation of Drugs by Electro-Hydro-Dynamic Atomization, Int. J. Pharm., vol. 324, no. 1,pp. 51-55,2006.

  6. de la Mora, J.F. and Loscertales, I.G., The Current Emitted by Highly Conducting Taylor Cones, J. Fluid Mech., vol. 260, pp. 155-184,1994.

  7. Fenn, J.B., Electrospray Wings for Molecular Elephants (Nobel Lecture), Angew. Chem, Int. Ed., vol. 42, no. 33, pp. 3871-3894,2003.

  8. Ganan-Calvo, A.M., The Surface Charge in Electrospraying: Its Nature and Its Universal Scaling Laws, J. Aerosol Sci., vol. 30, no. 7, pp. 863-872,1999.

  9. Hartman, R.P.A., Brunner, D.J., Camelot, D.M.A., Marijnissen, J.C.M., and Scarlett, B., Electrohydrodynamic Atomization in the Cone-Jet Mode Physical Modeling of the Liquid Cone and Jet, J. Aerosol Sci., vol. 30, no. 7, pp. 823-849,1999.

  10. Hayati, I., Bailey, A.I., and Tadros, T.F., Investigations into the Mechanisms of Electrohydrodynamic Spraying of Liquids: I. Effect of Electric Field and the Environment on Pendant Drops and Factors Affecting the Formation of Stable Jets and Atomization, J. Colloid Interface Sci., vol. 117, no. 1, pp. 205-221,1987.

  11. Jaworek, A. and Krupa, A., Classification of the Modes of EHD Spraying, J. Aerosol Sci., vol. 30, no. 7, pp. 873-893,1999.

  12. Jaworek, A., and Krupa, A., Main Modes of Electrohydrodynamic Spraying of Liquids, in Proc. of Third Int. Conf. on Multiphase Flow, pp. 8-12,1998.

  13. Jones, A.R. and Thong, K.C., The Production of Charged Monodisperse Fuel Droplets by Electrical Dis-persion, J. Phys. D: Appl. Phys., vol. 4, no. 8, p. 1159,1971.

  14. Kim, H.H., Teramoto, Y., Negishi, N., Ogata, A., Kim, J.H., Pongrac, B., Machala, Z. and Ganan-Calvo, A.M., Polarity Effect on the Electrohydrodynamic (EHD) Spray of Water, J. Aerosol Sci., vol. 76, pp. 98-114,2014.

  15. Krpoun, R., Micromachined Electrospray Thrusters for Spacecraft Propulsion, PhD, EPFL, 2009.

  16. Li, C., Chang, M., Yang, W., Madden, A., and Deng, W., Ballpoint Pen Tips as Robust Cone-Jet Electrospray Emitters, J. Aerosol Sci., vol. 77, pp. 10-15,2014.

  17. Martin, S., Perea, A., Garcia-Ybarra, P.L., and Castillo, J.L., Effect of the Collector Voltage on the Stability of the Cone-Jet Mode in Electrohydrodynamic Spraying, J. Aerosol Sci., vol. 46, pp. 53-63,2012.

  18. Naderi, P., Shams, M., and Ghassemi, H., Investigation on the Onset Voltage and Stability Island of Electrospray in the Cone-Jet Mode Using Curved Counter Electrode, J. Electrost., vol. 98, pp. 1-10, 2019.

  19. Paine, M.D., Alexander, M.S., Smith, K.L., Wang, M., and Stark, J.P.W., Controlled Electrospray Pulsation for Deposition of Femtoliter Fluid Droplets onto Surfaces, J. Aerosol Sci., vol. 38, no. 3, pp. 315-324, 2007.

  20. Parhizkar, M., Reardon, P.J.T., Knowles, J.C., Browning, R.J., Stride, E., Barbara, P.R., Harker, A.H., and Edirisinghe, M., Electrohydrodynamic Encapsulation of Cisplatin in Poly (Lactic-Co-Glycolic Acid) Nanoparticles for Controlled Drug Delivery, Nanomedicine, vol. 12, no. 7, pp. 1919-1929,2016.

  21. Park, H., Kim, K., and Kim, S., Effects of a Guard Plate on the Characteristics of an Electrospray in the Cone-Jet Mode, J. Aerosol Sci, vol. 35, no. 11, pp. 1295-1312,2004.

  22. Rosell-Llompart, J., Grifoll, J., and Loscertales, I.G., Electrosprays in the Cone-Jet Mode: From Taylor Cone Formation to Spray Development, J. Aerosol Sci., vol. 125, pp. 2-31,2018.

  23. Rulison, A.J. and Flagan, R.C., Scale-Up of Electrospray Atomization Using Linear Arrays of Taylor Cones, Rev. Sci. Instrum., vol. 64, no. 3, pp. 683-686,1993.

  24. Smith, D.P.H., The Electrohydrodynamic Atomization of Liquids, IEEE Trans. Ind. Appl., vol. 22, no. 3, pp. 527-535,1986.

  25. Taylor, G.I., Disintegration of Water Drops in an Electric Field, ProcR. Soc. London, Ser. A, vol. 280, no. 1382, pp. 383-397,1964.

  26. Ueda, H., Takeuchi, K., and Kikuchi, A., Effect of the Nozzle Tip's Geometrical Shape on Electrospray Deposition of Organic ThinFilms, Jpn. J. Appl. Phys, vol. 56, no. 4S, p. 04CL05,2017.

  27. Wang, Z., Xia, L., Tian, L., Wang, J., Zhan, S., Huo, Y., and Tu, J., Natural Periodicity of Electrohydrodynamic Spraying in Ethanol, J. Aerosol Sci., vol. 117, pp. 127-138,2018.

  28. Zhao, X.-Y., Li, C., Yang, W., and Deng, W., Based Electrospray Emitters, J. Aerosol Sci., vol. 113, pp. 108-113,2017.

对本文的引用
  1. Ma Dongyun, Chang Shinan, Yang Chen, Investigation on Film Formation Characteristics of Pressure-Swirl Nozzle, Coatings, 11, 7, 2021. Crossref

Begell Digital Portal Begell 数字图书馆 电子图书 期刊 参考文献及会议录 研究收集 订购及政策 Begell House 联系我们 Language English 中文 Русский Português German French Spain