图书馆订阅: Guest
Begell Digital Portal Begell 数字图书馆 电子图书 期刊 参考文献及会议录 研究收集
雾化与喷雾
影响因子: 1.737 5年影响因子: 1.518 SJR: 0.814 SNIP: 1.18 CiteScore™: 2.2

ISSN 打印: 1044-5110
ISSN 在线: 1936-2684

卷:
卷 30, 2020 卷 29, 2019 卷 28, 2018 卷 27, 2017 卷 26, 2016 卷 25, 2015 卷 24, 2014 卷 23, 2013 卷 22, 2012 卷 21, 2011 卷 20, 2010 卷 19, 2009 卷 18, 2008 卷 17, 2007 卷 16, 2006 卷 15, 2005 卷 14, 2004 卷 13, 2003 卷 12, 2002 卷 11, 2001 卷 10, 2000 卷 9, 1999 卷 8, 1998 卷 7, 1997 卷 6, 1996 卷 5, 1995 卷 4, 1994 卷 3, 1993 卷 2, 1992 卷 1, 1991

雾化与喷雾

DOI: 10.1615/AtomizSpr.v12.i4.50
pages 431-449

CHARACTERISTICS OF INTERIMPINGEMENT DIESEL SPRAY

Takayuki Chiba
Department of Mechanical System Engineering, Gunma University, Kiryu, Gunma, Japan
Masahiro Saito
Department of Mechanical System Engineering, Gunma University, Kiryu, Gunma, Japan
Kenji Amagai
Department of Mechanical System Engineering, Gunma University, Kiryu, Gunma, Japan
Masataka Arai
Division of Mechanical Science and Technology, Faculty of Science and Technology, Gunma University, 1-5-1 Tenjin-cho, Kiryu, Gunma, 376-8515, Japan; Tokyo Denki University

ABSTRACT

A mutual impingement of spray in a diesel engine was tried to assess the probability of further atomization of conventional diesel spray. The effects of impingement distance and impingement angle on the characteristics of the impingement spray were investigated by comparing with a nonimpingement free spray. In this study, the experiment was conducted for two typical impingement patterns, the jet-to-jet impingement of liquid columns in the vicinity of the nozzles and the spray-to-spray impingement of fully developed sprays away from the nozzles. The spray tip penetration was reduced rapidly after the impingement in both cases of jet-to-jet and spray-to-spray impingements with impingement angle of 90°. On the other hand, in the case of spray-to-spray impingement with 60° impingement, the penetrations were longer than that of free spray at just after the impingement. Spray tip velocity was calculated by differentiating the spray tip penetration curve. In the case of 90' impingement, the spray tip velocity was reduced rapidly by the impingement. However, in the case of spray-to-spray impingement with 60' impingement, the impinged spray had a tendency to increase instantaneously just after the impingement. This means that the spray may be accelerated by the mutual impingement. Atomization behavior was observed using a high-speed camera and it was found that the mutual impingement of diesel sprays caused the swelling of the sprays after the impingement. So, a simple model for estimation of impinging spray volume was proposed. The spray volume was about 1.5 times larger than that of free spray when the impingement distance was near the breakup point of the free spray. Also, the Sauter mean diameter (SMD) of the impingement spray was compared with that of nonimpingement free spray. The result showed that the SMD was slightly smaller compared with that of the free spray in the case of spray-to-spray impingement.


Articles with similar content:

ATOMIZATION CHARACTERISTICS OF JET-TO-JET AND SPRAY-TO-SPRAY IMPINGEMENT SYSTEMS
Atomization and Sprays, Vol.9, 1999, issue 4
Masataka Arai, Masahiro Saito
EFFECTS OF CROSS-FLOW ON FUEL SPRAY INJECTED BY HOLE-TYPE INJECTOR FOR DIRECTINJECTION GASOLINE ENGINE
Atomization and Sprays, Vol.25, 2015, issue 1
Youichi Ogata, Keiya Nishida, Ryousuke Kishi, Min Guo, Baolu Shi
DIESEL SPRAY IMPINGING ON A FLAT WALL. PART II: VOLUME AND AVERAGE AIR-FUEL RATIO OF AN IMPINGEMENT DIESEL SPRAY
Atomization and Sprays, Vol.12, 2002, issue 5&6
Masataka Arai, Kyungnam Ko
THE CHARACTERISTICS OF POSTIMPINGEMENT DIESEL SPRAY, PART II: EMPIRICAL EQUATION OF PENETRATION
Atomization and Sprays, Vol.12, 2002, issue 4
Masataka Arai, Kyungnam Ko
THE CHARACTERISTICS OF POSTIMPINGEMENT DIESEL SPRAY, PART I: PENETRATION AND VOLUME
Atomization and Sprays, Vol.12, 2002, issue 4
Masataka Arai, Kyungnam Ko