图书馆订阅: Guest
Begell Digital Portal Begell 数字图书馆 电子图书 期刊 参考文献及会议录 研究收集
传热学
影响因子: 1.199 5年影响因子: 1.155 SJR: 0.267 SNIP: 0.503 CiteScore™: 1.4

ISSN 打印: 1064-2285
ISSN 在线: 2162-6561

卷:
卷 51, 2020 卷 50, 2019 卷 49, 2018 卷 48, 2017 卷 47, 2016 卷 46, 2015 卷 45, 2014 卷 44, 2013 卷 43, 2012 卷 42, 2011 卷 41, 2010 卷 40, 2009 卷 39, 2008 卷 38, 2007 卷 37, 2006 卷 36, 2005 卷 35, 2004 卷 34, 2003 卷 33, 2002 卷 32, 2001 卷 31, 2000 卷 30, 1999 卷 29, 1998 卷 28, 1997

传热学

DOI: 10.1615/HeatTransRes.2012005687
pages 115-131

EXPERIMENTAL STUDY OF CONTACT ANGLE AND ACTIVE NULEATION SITE DISTRIBUTION ON NANOSTRUCTURE MODIFIED COPPER SURFACE IN POOL BOILING HEAT TRANSFER ENHANCEMENT

Eric Nolan
Department of Mechanical Engineering, Villanova University, Villanova, PA 19085, USA
Russell Rioux
Department of Mechanical Engineering, Villanova University, Villanova, PA 19085, USA
Pei-Xue Jiang
Beijing Key Laboratory for CO2 Utilization and Reduction Technology; Key Laboratory for Thermal Science and Power Engineering of Ministry of Education Department of Thermal Engineering, Tsinghua University, Beijing 100084, China
G. P. "Bud" Peterson
Georgia Institute of Technology
Calvin Hong Li
Department of Mechanical Engineering, Villanova University, Villanova, PA 19085, USA

ABSTRACT

A comparison study of heat transfer coefficient (HTC) and critical heat flux (CHF) on nanostructure modified Cu surfaces in terms of nucleation site density and contact angle that significantly influence pool boiling heat transfer of water on copper surfaces has been conducted. The nanostructures on copper surfaces have been created by an electrodeposition technique. It has been found that the nanostructured copper surfaces show an increase in the CHF of up to 142% and an increase in the HTC of 33% over that of a mirror-finished plain copper surface. Calculations for nucleation site density and active nucleation site diameter reveal a direct correlation between these factors and the HTC, as well as the CHF. More interestingly, a contact angle study and active nucleation site calculation on the tested surfaces show that there are strong connections between the contact angle reduction and active nucleation site increase, and CHF enhancement and HTC raise, which confirm the contact angle mechanism of CHF and active nucleation site mechanism of HTC on nanoscale surface structures.


Articles with similar content:

CONTROL OF POOL BOILING HYDRODYNAMICS THROUGH SURFACE WETTABILITY PATTERNING
International Heat Transfer Conference 16, Vol.4, 2018, issue
Taylor P. Allred, Suresh V. Garimella, Justin A. Weibel
NUCLEATE BOILING ON THE SUPERHYDROPHILIC SURFACE WITH A SMALL WATER IMPINGEMENT JET
International Heat Transfer Conference 13, Vol.0, 2006, issue
Yuhao Qiu, Zhenhua Liu
NUCLEATE POOL BOILING ON OXIDIZED TUBES
International Heat Transfer Conference 10, Vol.12, 1994, issue
Kwang T. Hong, Ralph L. Webb, Harris E. Imadojemu
NUCLEATE AND FILM BOILING HEAT TRANSFER IN R11: THE EFFECTS OF ENHANCED SURFACES AND INCLINATION
International Heat Transfer Conference 8, Vol.4, 1986, issue
D. S. Jung, James E. S. Venart, Antonio C. M. Sousa
EFFECT OF SURFACE WETTABILITY ON TRANSITION BOILING HEAT TRANSFER FROM A VERTICAL SURFACE
International Heat Transfer Conference 8, Vol.4, 1986, issue
Dean Vijay K. Dhir, Shih-Pin Liaw