图书馆订阅: Guest
Begell Digital Portal Begell 数字图书馆 电子图书 期刊 参考文献及会议录 研究收集
传热学
影响因子: 1.199 5年影响因子: 1.155 SJR: 0.267 SNIP: 0.503 CiteScore™: 1.4

ISSN 打印: 1064-2285
ISSN 在线: 2162-6561

卷:
卷 51, 2020 卷 50, 2019 卷 49, 2018 卷 48, 2017 卷 47, 2016 卷 46, 2015 卷 45, 2014 卷 44, 2013 卷 43, 2012 卷 42, 2011 卷 41, 2010 卷 40, 2009 卷 39, 2008 卷 38, 2007 卷 37, 2006 卷 36, 2005 卷 35, 2004 卷 34, 2003 卷 33, 2002 卷 32, 2001 卷 31, 2000 卷 30, 1999 卷 29, 1998 卷 28, 1997

传热学

DOI: 10.1615/HeatTransRes.v41.i7.40
pages 737-752

Turbine Airfoil Aerothermal Characteristics in Future Coal—Gas-Based Power Generation Systems

MinKing K. Chyu
Department of Mechanical Engineering and Materials Science University of Pittsburgh, Pittsburgh, PA 15261, USA
Mary Anne Alvin
National Energy Technology Laboratory, U.S. Department of Energy, Pittsburgh, PA 15236, USA

ABSTRACT

Most promising operating cycles being developed for future coal—gas-based systems are hydrogen-fired cycle and oxy-fuel cycle. Both cycles will likely have turbine working fluids significantly different from those of conventional air-based gas turbines. The oxy-fuel cycle, with steam and CO2 as a primary working fluid in the turbine section, will have a turbine inlet temperature target at approximately 1750°C, significantly higher than the current level of utility turbine systems. Described in this paper is a CFD-based simulation of the transport phenomena around the gas side of a turbine airfoil under realistic operating conditions of future coal—gas-based systems. The relatively high concentration of steam in the oxy-fuel turbine leads to approximately 40% higher heat transfer coefficient on the airfoil external surface than its hydrogen-fired counterpart. This suggests that advances in cooling technology and thermal barrier coatings (TBC) are critical for the developments of future coal-based turbine systems. To further explore this issue, a comparative study on the internal cooling effectiveness between a double-wall or skin-cooled arrangement and an equivalent serpentine-cooled configuration is performed. The contribution of thermal barrier coatings (TBC) toward overall thermal protection for turbine airfoil cooled under these two different cooling configurations is also evaluated.


Articles with similar content:

TURBINE AIRFOIL AEROTHERMAL CHARACTERISTICS IN FUTURE COAL-GAS BASED POWER GENERATION SYSTEMS
ICHMT DIGITAL LIBRARY ONLINE, Vol.0, 2009, issue
MinKing K. Chyu, Mary Anne Alvin
Recent Studies in Turbine Blade Internal Cooling
Heat Transfer Research, Vol.41, 2010, issue 8
Michael Huh, Je-Chin Han
RECENT STUDIES IN TURBINE BLADE INTERNAL COOLING
ICHMT DIGITAL LIBRARY ONLINE, Vol.0, 2009, issue
Michael Huh, Je-Chin Han
HEAT TRANSFER ENHANCEMENT FOR TURBINE BLADE INTERNAL COOLING
Journal of Enhanced Heat Transfer, Vol.21, 2014, issue 2-3
Lesley M. Wright, Je-Chin Han
Augmented Heat Transfer of an Internal Blade Tip by Full or Partial Arrays of Pin-Fins
Heat Transfer Research, Vol.42, 2011, issue 1
Bengt Sunden, Lieke Wang, Esa Utriainen, Gongnan Xie